The FIA’s report into Jules Bianchi’s crash during the Japanese Grand Prix, which left him with serious brain injuries, claims it occurred because the Marussia driver “did not slow sufficiently” as he was instructed to by double yellow flags which were being shown at the time.
“If drivers adhere to the requirements of double yellow flags,” the report noted, “then neither competitors nor officials should be put in immediate or physical danger”. Bianchi’s car struck a crane which was recovering the stranded vehicle of Adrian Sutil, who had crashed at the same corner on the previous lap.
But although the report backed the decision of race director Charlie Whiting not to deploy the Safety Car while Sutil’s car was being recovered, a summary released following today’s World Motor Sport Council meeting listed six recommendations for improvements to F1 safety in the wake of the accident. They included changes to the use of double waved yellow flags.
The report also revealed a conflict between the Marussia’s brake-by-wire system and a failsafe system on the car may have hindered Bianchi’s efforts to slow down prior to the moment of impact.
The Marussia driver lost control of his car in the Dunlop curve, slightly earlier than where Sutil had gone off. His helmet made contact with the underside of the crane which was moving Sutil’s car.
The report’s authors judged it was not realistic to attempt to make such an impact safe by enclosing cockpits or modifying recovery vehicles. “It is not feasible to mitigate the injuries Bianchi suffered by either enclosing the driver’s cockpit, or fitting skirts to the crane,” they noted. “Neither approach is practical due to the very large forces involved in the accident between a 700kg car striking a 6500kg crane at a speed of 126kph [78mph].”
Nonetheless it did not take the position that the Safety Car should have been deployed because a crane was being used at the side.
“The actions taken following Sutil’s accident were consistent with the regulations, and their interpretation following 384 incidents in the preceding eight years,” it judged. “Without the benefit of hindsight, there is no apparent reason why the Safety Car should have been deployed either before or after Sutil’s accident.”
Instead the recommendations made by the sport’s governing body included changes to yellow flag procedure, improvements to track drainage and changes to the scheduling of races to avoid local rainy seasons. Bianchi’s crash occurred around three-quarters of an hour before sunset was due to fall, with heavy cloud and rain further worsening visibility.
Although the report stressed “the characteristics of the wet weather tyres provided by Pirelli did not influence Bianchi’s accident or its outcome in any significant way”, it also advised for changes to be made to ensure wet weather tyres can be adequately tested.
The actions of the marshals at the scene of both crashes and the medical attention Bianchi received was judged to be in line with all relevant procedures. “Their expediency are considered to have contributed significantly to the saving of Bianchi’s life,” the report noted.
A ten-man panel contributed to the report including the president of the FIA Safety Commission Peter Wright, former team principals Ross Brawn and Stefano Domenicali and two-times world champion Emerson Fittipaldi.
Bianchi, who remains unconscious and in a critical condition, returned to France last month.
Jules Bianchi crash report summary
As issued by the FIA.
On lap 43 of the Japanese Grand Prix, Jules Bianchi lost control of his Marussia in turn seven, and struck a mobile crane that was recovering Adrian Sutil’s Sauber, which had crashed the lap before. Bianchi suffered life-threatening injuries to his head, and was evacuated to hospital by ambulance.
The weather conditions at the time were rain and a deteriorating track condition, and the section of the track where the accident occurred was subject to double yellow flags, due to Sutil’s crash.
A review of all the evidence and other information about the events leading up to Bianchi’s accident has been carried out by the ten-man Accident Panel, appointed by the FIA. The panel has issued a 396-page report on their findings with recommendations for improvements, many relevant to all of motorsport. This has been presented to the FIA World Motor Sport Council.
The review of the events leading up to Bianchi’s accident indicate that a number of key issues occurred, which may have contributed to the accident, though none alone caused it:
1. The semi-dry racing line at turn seven was abruptly narrowed by water draining onto the track and flowing downhill along it. Both Sutil, and Bianchi one lap later, lost control at this point in turn seven.
2. Sutil’s car was in the process of being recovered by mobile crane when Bianchi approached sectors seven and eight, which include the part of turn seven where the recovery was taking place. Sectors seven and eight were subject to double yellow flags.
3. Bianchi did not slow sufficiently to avoid losing control at the same point on the track as Sutil.
4. If drivers adhere to the requirements of double yellow flags, as set out in Appendix H, Article 188.8.131.52.b*, then neither competitors nor officials should be put in immediate or physical danger.
5. The actions taken following Sutil’s accident were consistent with the regulations, and their interpretation following 384 incidents in the preceding eight years. Without the benefit of hindsight, there is no apparent reason why the Safety Car should have been deployed either before or after Sutil’s accident.
6. Bianchi over-controlled the oversteering car, such that he left the track earlier than Sutil, and headed towards a point “up-stream” along the barrier. Unfortunately, the mobile crane was in front of this part of the barrier, and he struck and under-ran the rear of it at high speed.
7. During the two seconds Bianchi’s car was leaving the track and traversing the run-off area, he applied both throttle and brake together, using both feet. The FailSafe algorithm is designed to over-ride the throttle and cut the engine, but was inhibited by the Torque Coordinator, which controls the rear Brake-by-Wire system. Bianchi’s Marussia has a unique design of BBW, which proved to be incompatible with the FailSafe settings.
8. The fact that the FailSafe did not disqualify the engine torque requested by the driver may have affected the impact velocity; it has not been possible to reliably quantify this. However, it may be that Bianchi was distracted by what was happening and the fact that his front wheels had locked, and been unable to steer the car such that it missed the crane.
9. Bianchi’s helmet struck the sloping underside of the crane. The magnitude of the blow and the glancing nature of it caused massive head deceleration and angular acceleration, leading to his severe injuries.
10. All rescue and medical procedures were followed, and their expediency are considered to have contributed significantly to the saving of Bianchi’s life.
11. It is not feasible to mitigate the injuries Bianchi suffered by either enclosing the driver’s cockpit, or fitting skirts to the crane. Neither approach is practical due to the very large forces involved in the accident between a 700kg car striking a 6500kg crane at a speed of 126kph. There is simply insufficient impact structure on a F1 car to absorb the energy of such an impact without either destroying the driver’s survival cell, or generating non-survivable decelerations.
It is considered fundamentally wrong to try and make an impact between a racing car and a large and heavy vehicle survivable. It is imperative to prevent a car ever hitting the crane and/or the marshals working near it.
A number of recommendations for improvements have been proposed, relevant in many cases to all of motorsport. They include the following:
1. A new regulation for double yellow flags:
Proposed new Appendix H Article (possibly under 184.108.40.206 b):
The Clerk of the Course will impose a speed limit in any section of track where double yellow flags are being displayed.
It is proposed that a Working Group, made up of FIA race directors and stewards should meet and draw up detailed regulations and guidelines for the application of this new regulation, in time to apply it in 2015 across international circuit racing.
2. Safety critical software:
A review of safety critical software and measures to check its integrity will take place.
3. Track drainage:
Guidelines on circuit drainage will be reviewed, to include drainage off access roads.
4. 4-hour Rule:
Article 5.3 of the F1 sporting regulations states that:
However, should the race be suspended (see Article 41) the length of the suspension will be added to this period up to a maximum total race time of four hours.
It is proposed that a regulation or guideline be established such that the start time of an event shall not be less than four hours before either sunset or dusk, except in the case of night races.
It is also recommended that the F1 calendar is reviewed in order to avoid, where possible, races taking place during local rainy seasons.
5. Super Licence
It is proposed that drivers acquiring a super licence for the first time should undertake a course to familiarise themselves with the procedures used by F1 in running and ensuring the safety of an event.
It is also proposed that new licence holders pass a test to ensure that they are familiar with all the relevant regulations.
6. F1 risk review
Consideration will be given to a review of F1 risk, in order to ascertain whether there are any significant holes in the safety defences, such that an unforeseen combination of circumstances could result in a serious accident.
It is part of the challenge of a racing driver to drive his car as fast as possible given the track conditions combined with the characteristics of his tyres. Although the characteristics of the wet weather tyres provided by Pirelli did not influence Bianchi’s accident or its outcome in any significant way, it is recommended that provision is made for the tyre supplier to develop and adequately test wet weather tyres between each F1 season, such that it is able to supply the latest developments to the first event.
*Appendix H, Article 220.127.116.11.b of the International Sporting Code defines a double waved yellow flag as follows:
“Reduce your speed, do not overtake, and be prepared to change direction or stop. There is a hazard wholly or partly blocking the track.”
2014 Japanese Grand Prix
- Bianchi’s fight for life ends nine months after Japanese Grand Prix crash
- Streiff’s comments on Bianchi crash investigation prompts legal action from FIA
- No improvement in Bianchi’s condition
- FIA plans changes after Bianchi crash but report says his speed was to blame
- Bianchi returns to France but condition still “critical”